More ec 200 problems

[gump147]

Well I thought it was fixed but guess not it will start up and run for about 5 min then it quits like it runs out of fuel but it quits getting spark I let it set for a few minutes (less than 5) and it gets spark again and will run for 5 more minutes or less where to start stator coil cdi ecu or just wires I'm lost when it comes to this kind of problem thanks for any help

 

[Thomas R]

Breater in the gas cap is blocked. Mine did the same

 

[Thomas R]

Sorry did not se the misding spark thing, could i be the ignition coil, when broken they usualy fail when getting hot.

 

[gump147]

Sorry did not se the misding spark thing, could i be the ignition coil, when broken they usualy fail when getting hot.

The ignition coil is what the spark plug wire comes from right I no its probe a stupid question but I've looked at so many things I think I've confused myself thanks

 

[gump147]

ec200 problems

Sorry did not se the misding spark thing, could i be the ignition coil, when broken they usualy fail when getting hot.

Also another dumb question are the ignition coils bike specific can I try on off of one of my other bikes they look the same

 

[Thomas R]

It is if you got some freeze in a can you can give it a spray, compresed air i a can turned up side down should do the trick as well. Stupid fault to find.

 

[thejackrabbit]

check the kill switch, I had to solder it back together on the bars at one point, maybe its acting up, it never did for me though

 

[gump147]

ec200

check the kill switch, I had to solder it back together on the bars at one point, maybe its acting up, it never did for me though

Thanks ill check there as well I'm in the process of checking resistance on everything and tracing all wires ill keep everyone informed

 

[thejackrabbit]

also check the yellow wire by the top shock mount on the left side if sitting on the bike, I remember it becoming exposed at one point and I covered it with electrical tape but that may have fallen off now causing a short?

 

[gump147]

ec200

also check the yellow wire by the top shock mount on the left side if sitting on the bike, I remember it becoming exposed at one point and I covered it with electrical tape but that may have fallen off now causing a short?

Ok thanks I'm trying everything never had anything like this happen some are saying its the stator but in my experience when there bad there bad but I could be wrong ill try that wire as well thanks any other advice is welcome